Bosch SM070 Specifications Page 17
- Page / 100
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
Vertical Configurability | 17SM Series Heat Pump
6 720 220 406 (2013/9)Revised 08-13
Blower Re-Configuration
1. Remove and retain diagonal support brackets
on Front and Back sides of the unit. (Figure
#47)
Figure # 47
2. Unplug electrical connections of Blower motor
and ground wire connected to blower housing.
(Figure #48)
Figure # 48
3. Remove and retain blower motor and inlet ring
assembly by removing (3) bolts securing
blower motor bracket and screws securing the
blower inlet ring. (Figure #49)
Figure # 49
4. Remove screws on both sides of the blower
securing vertical blower bracket to horizontal
support.(Figure#50)
Figure # 50
5. Remove and retain blower assembly by lifting
up. (Figure #51)
This instruction details re-configuration of
blower from UP to SIDE discharge. Re-
configuration to other side uses similar steps.
Removing the blower motor and blower wheel
greatly simplifies handling of the blower
assembly and reduces the chance of damaging
heat pump components.
Air coil is in close proximity to the blower
and air coil fins are easily damaged. Great
care must be taken during this step to avoid
coil damage. Shipping cardboard can be
used as protection during blower removal
and installation.
- SM Series Heat pump 1
- CONTENTS 2
- MODEL NOMENCLATURE 3
- Figure # 2 4
- GENERAL DESCRIPTION 5
- MOVING AND STORAGE 6
- INITIAL INSPECTION 6
- LOCATION 6
- Figure # 4 7
- Figure # 5 7
- Figure # 6 7
- Figure # 7 7
- Figure # 20 10
- Figure # 21 10
- Figure # 22 10
- Figure # 23 10
- Figure # 24 10
- Figure # 27 11
- Figure # 28 11
- Figure # 29 11
- Figure # 25 11
- Figure # 26 11
- Figure # 30 12
- Figure # 31 12
- Figure # 32 12
- Figure # 33 12
- Figure # 34 12
- COUNTER-FLOW CONFIGURABILITY 13
- VERTICAL CONFIGURABILITY 13
- Figure # 39 Back Discharge 14
- Figure # 40 Side Discharge 14
- Figure # 41 14
- Required Tools 15
- Access to Internal Components 15
- Figure # 43 16
- Figure # 44 16
- Figure # 45 16
- Figure # 46 16
- Blower Re-Configuration 17
- Electric Heat Option 18
- Figure # 56 19
- Figure # 57 19
- Figure # 58 19
- Figure # 59 19
- Figure # 60 19
- Be sure to retain the spring 20
- HRP Switch Relocation 21
- Electric Heat Relocation 22
- Figure # 80 24
- Figure # 81 24
- Figure # 82 24
- Figure # 83 24
- Reinstall All Panels 25
- RETURN AND DISCHARGE DUCT 25
- MOUNTING VERTICAL UNITS 27
- MOUNTING HORIZONTAL UNITS 27
- CONDENSATE DRAIN 27
- DUCT SYSTEM 28
- ELECTRICAL 29
- Figure # 95 30
- Figure # 96 30
- Figure # 97 31
- Figure # 98 31
- ECM INTERFACE BOARD 33
- Airflow Selector 33
- Constant Torque Motors (ECM) 34
- Hot Gas Reheat (HGRH) 35
- Electric Heat 35
- Heat Recovery Package (HRP) 35
- Constant Airflow Motor 36
- DPS Water Flow Proving 36
- Pump Relay 36
- Comfort Alert Module 36
- HEAT RECOVERY PACKAGE 37
- Water Tank Preparation 37
- HR Water Piping 37
- Water Tank Refill 37
- Initial Start-Up 38
- SEQUENCE OF OPERATION 39
- Cooling Mode 39
- Heating Mode 39
- APPLICATION CONSIDERATIONS 41
- Well Water Systems 41
- Cooling Tower/Boiler Systems 41
- Figure # 104 42
- Geothermal Systems 43
- SYSTEM CHECKOUT 44
- UNIT START-UP 44
- MAINTENANCE 45
- UNIT CHECK-OUT SHEET 46
- Customer Data 46
- Unit Nameplate Data 46
- Operating Conditions 46
- Auxiliary Heat 46
- UPM Board LED Indications 47
- Unit Troubleshooting 47
- Compressor Ohms 49
- HRP Troubleshooting 50
- ELECTRONIC THERMOSTAT 51
- INSTALLATION 51
- OPERATING TEMPERATURES AND 52
- PRESSURES 52
- COOLING HEATING 53
- AIRFLOW TABLES 57
- (SM0**-***-*** 57
- Table(SM0**-***-***-A) 58
- WIRING DIAGRAMS 60
- Figure # 109 61
- Figure # 110 62
- Figure # 111 63
- Figure # 112 64
- Figure # 113 66
- Figure # 114 67
- WIRING HARNESS DRAWINGS 68
- Figure # 116 69
- SPARE PARTS LIST 70
- Vertical (VT) 70
- VT Parts List - Cabinet 72
- VT Parts List - Blower 73
- 6 720 220 408 (02) 74
- Horizontal (HZ) 77
- HZ Part List - Cabinet 79
- HZ Parts List - Blower 80
- HZ Parts List - Refrigeration 81
- HZ Part List - Panels 82
- HZ Part List - Detailed View 83
- Counter Flow Part List 84
- 6 720 220 430 (00) 86
- DIMENSIONAL DRAWINGS 91
- Horizontal - Straight Through 92
- Figure # 134 93
- Counter Flow 94
- Vertical 95
- Notes 97
- Notes 99
- Revised 08-13 100
Related products and manuals for Heat pumps Bosch SM070
Heat pumps Bosch EHP 6.5 AA User Manual
(84 pages)
(84 pages)
Heat pumps Bosch CP009 User Manual
(150 pages)
(150 pages)
Heat pumps Bosch SM024 Specifications
(41 pages)
(41 pages)
Heat pumps Bosch SM024 Specifications
(32 pages)
(32 pages)
Heat pumps Bosch TW Series Specifications
(24 pages)
(24 pages)
Heat pumps Bosch 7739832071 Brochure
(8 pages)
(8 pages)
Heat pumps Bosch BOVA-36HN1-M18M User Manual
(44 pages)
(44 pages)
Yamaha YAS-203 Handbücher
Bedienungsanleitungen und Benutzerhandbücher für CD Spieler Yamaha YAS-203.
Wir stellen PDF-Handbücher Yamaha YAS-203 zum kostenlosen herunterladen nach Dokumenttypen zur Verfügung
Comments to this Manuals