Bosch HBL56 Service Manual

SERVICE MANUAL for 300, 500, and 800 Series Built-in Wall Ovens This manual contains information tha

Service Manual for Bosch Built-in Wall Ovens 4.3 Lamps The operation of the cavity lights is determined by the state of the lights, the state of the

Service Manual for Bosch Built-in Wall Ovens 3. Pull the halogen bulb straight out from its socket. 4. Using a clean, dry cloth, insert the new b

Service Manual for Bosch Built-in Wall Ovens Page 12 of 36 The ring element (240V 2000W) and/or fan blade are easily accessed o

Service Manual for Bosch Built-in Wall Ovens 1. Press and hold Info for two seconds to access the Setup menu. 2. Remove the 2 T20 screws on either

Service Manual for Bosch Built-in Wall Ovens The user interface control board is assembled onto a chassis and the entire assembly is serviced as a s

Service Manual for Bosch Built-in Wall Ovens Figures 16 Relay locations on the double oven control module After installing a new user interface boa

Service Manual for Bosch Built-in Wall Ovens Use Table 6 as a reference guide to the plugs, pins, and wire colors found on the PC control module. P

Service Manual for Bosch Built-in Wall Ovens Table 6 Plugs and pins on the PC control module PLUG NO PIN NO FROM/TO 1-BU High Temperature Cutout (

Service Manual for Bosch Built-in Wall Ovens 4.12 Convection Fan Motor the module bracket from the 3 slots in the chassis. The convection fan motor

Service Manual for Bosch Built-in Wall Ovens 6. Tuck insulation up into the oven wall as necessary. If the Hall effect sensor does not detect fan r

Service Manual for Bosch Built-in Wall Ovens TABLE OF CONTENTS 1 General ...

Service Manual for Bosch Built-in Wall Ovens CODE DESCRIPTION CAUSE/ACTION E000 Wrong module combination Control module and user interface are m

Service Manual for Bosch Built-in Wall Ovens To set the option code… Figure 20 HBL3/HBN3 User interface 4. Locate the 4-digit code on the l

Service Manual for Bosch Built-in Wall Ovens 7 TROUBLESHOOTING 7. Follow the instructions on the oven display and enter the appropriate code. Use

Service Manual for Bosch Built-in Wall Ovens 7.1 Fault Tree Diagram Page 23 of 36

Service Manual for Bosch Built-in Wall Ovens Page 24 of 36

Service Manual for Bosch Built-in Wall Ovens Page 25 of 36 7.2 Fault Tree

Service Manual for Bosch Built-in Wall Ovens Page 26 of 36

Service Manual for Bosch Built-in Wall Ovens Page 27 of 36

Service Manual for Bosch Built-in Wall Ovens Page 28 of 36

Service Manual for Bosch Built-in Wall Ovens Page 29 of 36

Service Manual for Bosch Built-in Wall Ovens 1 GENERAL There are nine HBL (30”) and five HBN (27”) models in various combinations and three colors (

Service Manual for Bosch Built-in Wall Ovens Page 30 of 36

Service Manual for Bosch Built-in Wall Ovens Page 31 of 36

Service Manual for Bosch Built-in Wall Ovens Page 32 of 36

Service Manual for Bosch Built-in Wall Ovens 7.3 Testing Test with wire harness off at pin header or with circuits open. Plug Pins Operates Exp

Service Manual for Bosch Built-in Wall Ovens 9 ADDITIONAL REFERENCES 8.2 Strip Diagrams Figure 23 Upper (Cavity 1) / Single oven st

Service Manual for Bosch Built-in Wall Ovens 888 522-6724. Technicians are available to assist you Monday – Friday, between the hours of 5am and 5pm

Service Manual for Bosch Built-in Wall Ovens Notes 58300000139357 ARA EN B BSH Home Appliances Corporation Page 36 of 36 5551

Service Manual for Bosch Built-in Wall Ovens 1.3 Data Plate The data plate reflecting model number and FD number is located on the underside of the

Service Manual for Bosch Built-in Wall Ovens 2.1.1 Using Table 3 (Element Duty Cycles During Preheat) In Table 3, Dura

Service Manual for Bosch Built-in Wall Ovens Fi gure 3 Sequence of Events during Preheat: Convection Broil/Broil modes

Service Manual for Bosch Built-in Wall Ovens Page 7 of 36 Figure 5 Sequence of Events during Preheat: Sel

Service Manual for Bosch Built-in Wall Ovens 3 COMPONENT ACCESSIBILITY 3.1 Serviceable from Front  Door  Door latch/motor assembly  Cavity lamps

Service Manual for Bosch Built-in Wall Ovens To remove the door… 1. Open door completely. 2. Flip hinge levers back to open as shown below.